Modeling and Performance Evaluation of Three Power Generation and Refrigeration Energy Recovery Systems from Thermal Loss of a Diesel Engine in Different Driving Conditions
This paper investigates the possibility of using three systems of organic Rankine auxiliary power generation, ejector refrigeration and absorption to recover energy from a diesel car. The analysis is done for both urban and suburban driving modes that vary from 60 to 120 km/h. Various refrigerants have also been used for organic Rankine and Ejector refrigeration cycles. The capacity was evaluated by Organic Rankine Cycle (ORC) system in both urban and suburban conditions for cyclopentane and ammonia as refrigerants. Also, for these two driving plans, produced cooling by absorption refrigeration system under variable ambient temperature conditions and in ejector refrigeration system for R123, R134a and R141b refrigerants were investigated.
[1] Xu, F., Goswami, D.Y., Bhagwat, S.S., "A combined power/ cooling cycle", Energy, 25, 233–246, 2000.
[2] A. A. Hasan, D. Y. Goswami, and S. Vijayaraghavan, "First and second law analysis of a new power and refrigeration thermodynamic cycle using a solar heat source," Solar Energy, vol. 73, pp. 385-393, 2002.
[3] G. Tamm, D. Goswami, S. Lu, and A. Hasan, "Theoretical and experimental investigation of an ammonia–water power and refrigeration thermodynamic cycle," Solar Energy, vol. 76, pp. 217-228, 2004.
[4] A. Vidal, R. Best, R. Rivero, and J. Cervantes, "Analysis of a combined power and refrigeration cycle by the exergy method," Energy, vol. 31, pp. 3401-3414, 2006.
[5] S. Vijayaraghavan and D. Goswami, "A combined power and cooling cycle modified to improve resource utilization efficiency using a distillation stage," Energy, vol. 31, pp. 1177-1196, 2006.
[6] C. Martin and D. Goswami, "Effectiveness of cooling production with a combined power and cooling thermodynamic cycle," Applied Thermal Engineering, vol. 26, pp. 576-582, 2006.
[7] S. Sadrameli and D. Goswami, "Optimum operating conditions for a combined power and cooling thermodynamic cycle," Applied Energy, vol. 84, pp. 254-265, 2007.
[8] D. Zheng, B. Chen, Y. Qi, and H. Jin, "Thermodynamic analysis of a novel absorption power/cooling combined-cycle," Applied Energy, vol. 83, pp. 311-323, 2006.
[9] M. Liu and N. Zhang, "Proposal and analysis of a novel ammonia–water cycle for power and refrigeration cogeneration," Energy, vol. 32, pp. 961-970, 2007.
[10] N. Zhang and N. Lior, "Methodology for thermal design of novel combined refrigeration/power binary fluid systems," International Journal of Refrigeration, vol. 30, pp. 1072-1085, 2007.
[11] N. Zhang and N. Lior, "Development of a novel combined absorption cycle for power generation and refrigeration," Journal of Energy Resources Technology, vol. 129, pp. 254-265, 2007.
[12] J. Wang, Y. Dai, and L. Gao, "Parametric analysis and optimization for a combined power and refrigeration cycle," Applied energy, vol. 85, pp. 1071-1085, 2008.
[13] M. Ameri, A. Behbahaninia, and A. A. Tanha, "Thermodynamic analysis of a tri-generation system based on micro-gas turbine with a steam ejector refrigeration system," Energy, vol. 35, pp. 2203-2209, 2010/05/01/ 2010.
[14] J. Wang, Y. Dai, and Z. Sun, "A theoretical study on a novel combined power and ejector refrigeration cycle," International Journal of Refrigeration, vol. 32, pp. 1186-1194, 2009/09/01/ 2009.
[15] R. Yapıcı, "Experimental investigation of performance of vapor ejector refrigeration system using refrigerant R123," Energy Conversion and Management, vol. 49, pp. 953-961, 2008/05/01/ 2008.
[16] R. Yapıcı and C. C. Yetişen, "Experimental study on ejector refrigeration system powered by low grade heat," Energy Conversion and Management, vol. 48, pp. 1560-1568, 2007/05/01/ 2007.
[17] T. Sankarlal and A. Mani, "Experimental investigations on ejector refrigeration system with ammonia," Renewable Energy, vol. 32, pp1403-1413, 2007/07/01/ 2007.
[18] K. Pianthong, W. Seehanam, M. Behnia, T. Sriveerakul, and S. Aphornratana, "Investigation and improvement of ejector refrigeration system using computational fluid dynamics technique," Energy Conversion and Management, vol. 48, pp. 2556-2564, 2007/09/01/ 2007.
[19] H. Golchoobian, M. Amidpour, and O. Pourali, "Thermodynamic analysis of three combined power and refrigeration Systems based on a demand," Gas Processing, vol. 6, pp. 29-40, 2018.
[20] H. Golchoobian, A. Behbahaninia, M. Amidpour, and O. Pourali, "Dynamic Exergy Analysis of a Solar Ejector Refrigeration System with Hot Water Storage Tank," in Progress in Sustainable Energy Technologies: Generating Renewable Energy, I. Dincer, A. Midilli, and H. Kucuk, Eds., ed Cham: Springer International Publishing, 2014, pp. 327-337.
[21] C. Yue and P. Wang, "Thermal analysis on vehicle energy supplying system based on waste heat recovery ORC," Energy Procedia, vol. 158, pp. 5587-5595, 2019.
[22] S. G. Herawan, K. Talib, and A. Putra, "Prediction of heat energy from the naturally aspirated internal combustion engine exhaust gas using artificial neural network," Procedia Computer Science, vol. 135, pp. 267-274, 2018.
[23] B. Mashadi, A. Kakaee, and A. J. Horestani, "Low-temperature Rankine cycle to increase waste heat recovery from the internal combustion engine cooling system," Energy Conversion and Management, vol. 182, pp. 451-460, 2019.
[24] B. Patel, N. B. Desai, and S. S. Kachhwaha, "Optimization of waste heat based organic Rankine cycle powered cascaded vapor compression-absorption refrigeration system," Energy conversion and management, vol. 154, pp. 576-590, 2017.
[25] C. Yue, L. Tong, and S. Zhang, "Thermal and economic analysis on vehicle energy supplying system based on waste heat recovery organic Rankine cycle," Applied Energy, vol. 248, pp. 241-255, 2019.
[26] F. Salek, A. N. Moghaddam, and M. M. Naserian, "Thermodynamic analysis of diesel engine coupled with ORC and absorption refrigeration cycle," Energy Conversion and Management, vol. 140, pp. 240-246, 2017.
[27] J. Fu, J. Liu, R. Feng, Y. Yang, L. Wang, and Y. Wang, "Energy and exergy analysis on gasoline engine based on mapping characteristics experiment," Applied Energy, vol. 102, pp. 622-630, 2013.
[28] Y. Dai, J. Wang, and L. Gao, "Exergy analysis, parametric analysis and optimization for a novel combined power and ejector refrigeration cycle," applied thermal engineering, vol. 29, pp. 1983-1990, 2009.
[29] A. Ramanathan and P. Gunasekaran, "Simulation of Absorption Refrigeration System for Automobile Application," Thermal Science, vol. 12, pp. 5-13, 2008.
[30] R. E. Sonntag, C. Borgnakke, G. J. Van Wylen, and S. Van Wyk, Fundamentals of thermodynamics vol. 6: Wiley New York, 1998.
[31] S. Quoilin, M. Van Den Broek, S. Declaye, P. Dewallef, and V. Lemort, "Techno-economic survey of Organic Rankine Cycle (ORC) systems," Renewable and Sustainable Energy Reviews, vol. 22, pp. 168-186, 2013.
[32] T.-C. Hung, T. Shai, and S. K. Wang, "A review of organic Rankine cycles (ORCs) for the recovery of low-grade waste heat," Energy, vol. 22, pp. 661-667, 1997.
[33] P. Srikhirin, S. Aphornratana, and S. Chungpaibulpatana, "A review of absorption refrigeration technologies," Renewable and sustainable energy reviews, vol. 5, pp. 343-372, 2001.
[1] Xu, F., Goswami, D.Y., Bhagwat, S.S., "A combined power/ cooling cycle", Energy, 25, 233–246, 2000.
[2] A. A. Hasan, D. Y. Goswami, and S. Vijayaraghavan, "First and second law analysis of a new power and refrigeration thermodynamic cycle using a solar heat source," Solar Energy, vol. 73, pp. 385-393, 2002.
[3] G. Tamm, D. Goswami, S. Lu, and A. Hasan, "Theoretical and experimental investigation of an ammonia–water power and refrigeration thermodynamic cycle," Solar Energy, vol. 76, pp. 217-228, 2004.
[4] A. Vidal, R. Best, R. Rivero, and J. Cervantes, "Analysis of a combined power and refrigeration cycle by the exergy method," Energy, vol. 31, pp. 3401-3414, 2006.
[5] S. Vijayaraghavan and D. Goswami, "A combined power and cooling cycle modified to improve resource utilization efficiency using a distillation stage," Energy, vol. 31, pp. 1177-1196, 2006.
[6] C. Martin and D. Goswami, "Effectiveness of cooling production with a combined power and cooling thermodynamic cycle," Applied Thermal Engineering, vol. 26, pp. 576-582, 2006.
[7] S. Sadrameli and D. Goswami, "Optimum operating conditions for a combined power and cooling thermodynamic cycle," Applied Energy, vol. 84, pp. 254-265, 2007.
[8] D. Zheng, B. Chen, Y. Qi, and H. Jin, "Thermodynamic analysis of a novel absorption power/cooling combined-cycle," Applied Energy, vol. 83, pp. 311-323, 2006.
[9] M. Liu and N. Zhang, "Proposal and analysis of a novel ammonia–water cycle for power and refrigeration cogeneration," Energy, vol. 32, pp. 961-970, 2007.
[10] N. Zhang and N. Lior, "Methodology for thermal design of novel combined refrigeration/power binary fluid systems," International Journal of Refrigeration, vol. 30, pp. 1072-1085, 2007.
[11] N. Zhang and N. Lior, "Development of a novel combined absorption cycle for power generation and refrigeration," Journal of Energy Resources Technology, vol. 129, pp. 254-265, 2007.
[12] J. Wang, Y. Dai, and L. Gao, "Parametric analysis and optimization for a combined power and refrigeration cycle," Applied energy, vol. 85, pp. 1071-1085, 2008.
[13] M. Ameri, A. Behbahaninia, and A. A. Tanha, "Thermodynamic analysis of a tri-generation system based on micro-gas turbine with a steam ejector refrigeration system," Energy, vol. 35, pp. 2203-2209, 2010/05/01/ 2010.
[14] J. Wang, Y. Dai, and Z. Sun, "A theoretical study on a novel combined power and ejector refrigeration cycle," International Journal of Refrigeration, vol. 32, pp. 1186-1194, 2009/09/01/ 2009.
[15] R. Yapıcı, "Experimental investigation of performance of vapor ejector refrigeration system using refrigerant R123," Energy Conversion and Management, vol. 49, pp. 953-961, 2008/05/01/ 2008.
[16] R. Yapıcı and C. C. Yetişen, "Experimental study on ejector refrigeration system powered by low grade heat," Energy Conversion and Management, vol. 48, pp. 1560-1568, 2007/05/01/ 2007.
[17] T. Sankarlal and A. Mani, "Experimental investigations on ejector refrigeration system with ammonia," Renewable Energy, vol. 32, pp1403-1413, 2007/07/01/ 2007.
[18] K. Pianthong, W. Seehanam, M. Behnia, T. Sriveerakul, and S. Aphornratana, "Investigation and improvement of ejector refrigeration system using computational fluid dynamics technique," Energy Conversion and Management, vol. 48, pp. 2556-2564, 2007/09/01/ 2007.
[19] H. Golchoobian, M. Amidpour, and O. Pourali, "Thermodynamic analysis of three combined power and refrigeration Systems based on a demand," Gas Processing, vol. 6, pp. 29-40, 2018.
[20] H. Golchoobian, A. Behbahaninia, M. Amidpour, and O. Pourali, "Dynamic Exergy Analysis of a Solar Ejector Refrigeration System with Hot Water Storage Tank," in Progress in Sustainable Energy Technologies: Generating Renewable Energy, I. Dincer, A. Midilli, and H. Kucuk, Eds., ed Cham: Springer International Publishing, 2014, pp. 327-337.
[21] C. Yue and P. Wang, "Thermal analysis on vehicle energy supplying system based on waste heat recovery ORC," Energy Procedia, vol. 158, pp. 5587-5595, 2019.
[22] S. G. Herawan, K. Talib, and A. Putra, "Prediction of heat energy from the naturally aspirated internal combustion engine exhaust gas using artificial neural network," Procedia Computer Science, vol. 135, pp. 267-274, 2018.
[23] B. Mashadi, A. Kakaee, and A. J. Horestani, "Low-temperature Rankine cycle to increase waste heat recovery from the internal combustion engine cooling system," Energy Conversion and Management, vol. 182, pp. 451-460, 2019.
[24] B. Patel, N. B. Desai, and S. S. Kachhwaha, "Optimization of waste heat based organic Rankine cycle powered cascaded vapor compression-absorption refrigeration system," Energy conversion and management, vol. 154, pp. 576-590, 2017.
[25] C. Yue, L. Tong, and S. Zhang, "Thermal and economic analysis on vehicle energy supplying system based on waste heat recovery organic Rankine cycle," Applied Energy, vol. 248, pp. 241-255, 2019.
[26] F. Salek, A. N. Moghaddam, and M. M. Naserian, "Thermodynamic analysis of diesel engine coupled with ORC and absorption refrigeration cycle," Energy Conversion and Management, vol. 140, pp. 240-246, 2017.
[27] J. Fu, J. Liu, R. Feng, Y. Yang, L. Wang, and Y. Wang, "Energy and exergy analysis on gasoline engine based on mapping characteristics experiment," Applied Energy, vol. 102, pp. 622-630, 2013.
[28] Y. Dai, J. Wang, and L. Gao, "Exergy analysis, parametric analysis and optimization for a novel combined power and ejector refrigeration cycle," applied thermal engineering, vol. 29, pp. 1983-1990, 2009.
[29] A. Ramanathan and P. Gunasekaran, "Simulation of Absorption Refrigeration System for Automobile Application," Thermal Science, vol. 12, pp. 5-13, 2008.
[30] R. E. Sonntag, C. Borgnakke, G. J. Van Wylen, and S. Van Wyk, Fundamentals of thermodynamics vol. 6: Wiley New York, 1998.
[31] S. Quoilin, M. Van Den Broek, S. Declaye, P. Dewallef, and V. Lemort, "Techno-economic survey of Organic Rankine Cycle (ORC) systems," Renewable and Sustainable Energy Reviews, vol. 22, pp. 168-186, 2013.
[32] T.-C. Hung, T. Shai, and S. K. Wang, "A review of organic Rankine cycles (ORCs) for the recovery of low-grade waste heat," Energy, vol. 22, pp. 661-667, 1997.
[33] P. Srikhirin, S. Aphornratana, and S. Chungpaibulpatana, "A review of absorption refrigeration technologies," Renewable and sustainable energy reviews, vol. 5, pp. 343-372, 2001.
@article{"International Journal of Electrical, Electronic and Communication Sciences:79348", author = "H. Golchoobian and M. H. Taheri and S. Saedodin and A. Sarafraz", title = "Modeling and Performance Evaluation of Three Power Generation and Refrigeration Energy Recovery Systems from Thermal Loss of a Diesel Engine in Different Driving Conditions", abstract = "This paper investigates the possibility of using three systems of organic Rankine auxiliary power generation, ejector refrigeration and absorption to recover energy from a diesel car. The analysis is done for both urban and suburban driving modes that vary from 60 to 120 km/h. Various refrigerants have also been used for organic Rankine and Ejector refrigeration cycles. The capacity was evaluated by Organic Rankine Cycle (ORC) system in both urban and suburban conditions for cyclopentane and ammonia as refrigerants. Also, for these two driving plans, produced cooling by absorption refrigeration system under variable ambient temperature conditions and in ejector refrigeration system for R123, R134a and R141b refrigerants were investigated.
", keywords = "Absorption system, diesel engine, ejector refrigeration, energy recovery, organic Rankine cycle. ", volume = "13", number = "12", pages = "751-9", }
