Shaping the Input Side Current Waveform of a 3-ϕ Rectifier into a Pure Sine Wave

In this investigative research paper, we have presented the simulation results of a three-phase rectifier circuit to improve the input side current using the passive filters, such as capacitors and inductors at the output and input terminals of the rectifier circuit respectively. All simulation works were performed in a personal computer using the PSPICE simulator software, which is a virtual circuit design and simulation software package. The output voltages and currents were measured across a resistive load of 1 k. We observed that the output voltage levels, input current wave shapes, harmonic contents through the harmonic spectrum, and total harmonic distortion improved due to the use of such filters. 





References:
[1] A. R. Prasad, D. Phoivos, Ziogas, and S, Manias, “An active power factor correction technique for three phase diode rectifiers,” IEEE Trans. on Power Electronics, vol. 6, no.1, January 1999, pp. 83-91.
[2] A. I. Maswood, and E. Firmansyah, “Current injection in a controlled rectifier under unbalanced supply and variable line and load inductances,” IET Power Electron., 2009, vol. 2, no. 4, pp. 387-397.
[3] M. H. Rashid, “Power Electronics,” 3rd ed., Pearson, USA, 2011.
[4] C. L. Sulzberger, “Triumph of AC. 2. The battle of the currents,” IEEE Power and Energy Magazine, vol. 99, no. 4, pp. 70-73, July-Aug. 2003.
[5] W. He, F. Xue, F. Zheng, Y. Zhou, K. Liu, and Y. Tian, “Research on AC & DC hybrid power supply system with high-proportion renewable energy of data centre,” The Journal of Engineering, e-ISSN 2051-3305, Volume 2019, issue 16, March 2019, pp. 3230-3233, doi: 10.1049/ joe.2018.8925.
[6] H. Rissik, “Mercury-Arc Current Converters,” Pitman. 1941.
[7] M. R. Ahmed, Ruma and M. J. Alam, “Improvement of input side current of a three-phase rectifier using Cúk converter in Discontinuous Capacitor-Voltage Mode Operation”, 2nd IEEE International Conference on Power and Energy, Johor Baharu, Malaysia, 2008, pp. 1152-1155.
[8] D. Lu, X. Wang and F. Blaabjerg, “Investigation on the AC/DC Interactions in Voltage-Source Rectifiers and Current-Source Rectifiers,” 2018 IEEE 19th Workshop on Control and Modeling for Power Electronics (COMPEL), Padua, Italy, 2018, pp. 1-6, doi: 10.1109/COMPEL.2018.8460150.
[9] Asiya et al., “Generalized Analysis and Performance Investigation of the Class-E/Fn Rectifiers,” in IEEE Access, vol. 8, pp. 124145-124157, 2020, doi: 10.1109/ACCESS.2020.3005701.
[10] M. Jinno, W.-Lune Wu, and J. C. Doong, “Efficiency improvement for forward DC-DC converter employing synchronous rectifier,” IEEE 31st Annual Power Electronics Specialists Conference. Conference Proceedings (Cat. No.00CH37018), Galway, Ireland, 2000, pp. 1516-1521 vol.3, doi: 10.1109/PESC.2000.880531.
[11] A. Kaplon, and J. Rolek, “Analysis of multipulse rectifiers with modulation in DC circuit in vector space approach,” 13th International Power Electronics and Motion Control Conference, Poznan, Poland, 2008, pp. 377-382, doi: 10.1109/EPEPEMC.2008.4635294.
[12] R. Li, S. Yoshida, Y. Suzuki, H. Okazaki, and K. Nishikawa, “Investigation of Rectifier Operation with Harmonic Controlled Input Signals towards Pulse Modulation WiCoPT System,” IEEE International Symposium on Radio-Frequency Integration Technology, Hiroshima, Japan, 2020, pp. 187-189, doi: 10.1109/RFIT49453.2020.9226251.
[13] P. P. Nachankar, H. M. Suryawanshi, P. Chaturvedi, D. D. Atkar and P. Vijay Vardhan Reddy, “Investigation of Passive Rectifier Circuits for ModularSolid State Transformer Applications,” IEEE First International Conference on Smart Technologies for Power, Energy and Control, Nagpur, India, 2020, pp. 1-6, doi: 10.1109/STPEC49749.2020.9297717.
[14] C. Marouchos, M. Darwish, P. Panagiotis Dimitriadis, and A. Neroupou, “Investigation on line current compensation techniques for rectifier circuits,” 50th International Universities Power Engineering Conference, Stoke on Trent, UK, 2015, pp. 1-5, doi: 10.1109/UPEC.2015.7339828.
[15] J. C. Das, “Passive filters– potentialities and limitations,” IEEE Transactions on Industrial Applications, vol. 40, no. 1, January 2004, pp. 232-241.
[16] S. Jamali, M. A. S. Masoum and S. A. Mousavi, “Influence of controller high pass filter on the performance of shunt hybrid power filter,” Australasian Universities Power Engineering Conference, Sydney, NSW, Australia, 2008, pp. 1-6.
[17] G. Xiao, Y. Pei, K. Li, X. Yang, and Z. Wang, “A novel control approach to the DC active power filter used in a low ripple and large stable/pulse power supply,” IEEE 34th Annual Conference on Power Electronics Specialist (PESC), Acapulco, Mexico, 2003, vol. 4, pp. 1489-1493, doi: 10.1109/PESC.2003.1217674.
[18] J. C. Das, “Passive filters-potentialities and limitations,” Conference Record of the Annual Pulp and Paper Industry Technical Conference, 2003, Charleston, SC, USA, 2003, pp. 187-197, doi: 10.1109/PAPCON. 2003.1216916.
[19] J. C. Read, “The Calculations of Rectifier and Inverter Performance Characteristics,” JIEE, UK, 1943, pp. 495-509.
[20] D. A. Gonzalez and J. C. McCall, “Design of Filters to Reduce Harmonic Distortion in Industrial Power Systems,” IEEE Transactions on Industry Applications, vol. IA-23, no. 3, pp. 504-511, May 1987, doi: 10.1109/TIA.1987.4504938.
[21] S. George, V. Agarwal, “Effect of Harmonics on Reliability of Electrical Equipment,” International Conference on Quality, Reliability and Control, ICRC 2001, p. R687.
[22] D. Alexa, A. Sarbu, I. V. Pletea, C. Filote, and R. Chiper, “Variants of rectifiers with near sinusoidal input currents– a comparative analysis with the conventional diode rectifier,” IET Power Electronics, vol. 4, issue 6, pp. 632-641, 2011, The Institution of Engineering and Technology, doi: 10.1049/iet-pel.2010.0020.
[23] D. Sajeesh and S. George, “Power factor improvement in rectifier circuit — A simulation study,” Annual International Conference on Emerging Research Areas: Magnetics, Machines and Drives (AICERA/iCMMD), Kottayam, India, 2014, pp. 1-5, doi: 10.1109/AICERA.2014.6908237.
[24] R. Lai, F. Wang, R. Burgos, D. Boroyevich, D. Jiang and D. Zhang, “Average Modeling and Control Design for VIENNA-Type Rectifiers Considering the DC-Link Voltage Balance,” IEEE Transactions on Power Electronics, vol. 24, no. 11, pp. 2509-2522, Nov. 2009, doi: 10.1109/TPEL.2009.2032262.
[25] J. W. Kolar and F. C. Zach, “A novel three-phase utility interface minimizing line current harmonics of high-power telecommunications rectifier modules,” Proceedings of Intelec 94, 1994, pp. 367-374, doi: 10.1109/INTLEC.1994.396642.
[26] J. W. Kolar and U. Drofenik, “A new switching loss reduced discontinuous PWM scheme for a unidirectional three-phase/switch/ level boost-type PWM (VIENNA) rectifier,” 21st International Telecommunications Energy Conference. INTELEC1999 (Cat. No.99CH37007), 1999, pp. 572-, doi: 10.1109/INTLEC.1999.794128.
[27] P. Ide, F. Schafmeister, N. Frohleke and H. Grotstollen, “Enhanced control scheme for three-phase three-level rectifiers at partial load,” IEEE Transactions on Industrial Electronics, vol. 52, no. 3, pp. 719-726, June 2005, doi: 10.1109/TIE.2005.843959.
[28] G. Gong, M. L. Heldwein, U. Drofenik, J. Minibock, K. Mino and J. W. Kolar, “Comparative evaluation of three-phase high-power-factor AC-DC converter concepts for application in future More Electric Aircraft,” IEEE Transactions on Industrial Electronics, vol. 52, no. 3, pp. 727-737, June 2005, doi: 10.1109/TIE.2005.843957.
[29] U. Drofenik, G. Laimer and J. W. Kolar, “Pump Characteristic based optimization of a direct water cooling system for a 10-kW/500-kHz Vienna rectifier,” IEEE Transactions on Power Electronics, vol. 20, no. 3, pp. 704-714, May 2005, doi: 10.1109/TPEL.2005.846529.
[30] M. Malinowski, M. P. Kazmierkowski, S. Hansen, F. Blaabjerg and G. D. Marques, “Virtual-flux-based direct power control of three-phase PWM rectifiers,” IEEE Transactions on Industry Applications, vol. 37, no. 4, pp. 1019-1027, July-Aug. 2001, doi: 10.1109/28.936392.
[31] W.-L. Wu, C.-Y. Yang and D.-A. Wang, “A Flipping Active-Diode Rectifier for Piezoelectric-Vibration Energy-Harvesting,” European Conference on Circuit Theory and Design (ECCTD), Sofia, Bulgaria, 2020, pp. 1-4, doi: 10.1109/ECCTD49232.2020.9218313.
[32] C. Galup-Montoro, M. C. Schneider and M. B. Machado, “Ultra-Low-Voltage Operation of CMOS Analog Circuits: Amplifiers, Oscillators, and Rectifiers,” in IEEE Transactions on Circuits and Systems II: Express Briefs, vol. 59, no. 12, pp. 932-936, December 2012, doi: 10.1109/TCSII.2012.2231042.
[33] Y. Zhou, B. Froppier, and T. Razban, “Study of a matching circuit effect on a microwave rectifier,” 11th Mediterranean Microwave Symposium (MMS), Yasmine Hammamet, Tunisia, 2011, pp. 29-33, doi: 10.1109/ MMS.2011.6068522.
[34] J. V. Bapiraju, M. Giroux and J. Produkku, “Novel approach for modelling 3-level active rectifiers in real-time simulations,” IEEE International Conference on Power Electronics, Drives and Energy Systems (PEDES), Trivandrum, India, 2016, pp. 1-5, doi: 10.1109/ PEDES.2016.7914526.
[35] S. Porwal, P. Chhawchharia, and R. Pandey, “Simplified half wave rectifier model for improved laboratory simulation using PSpice,” International Conference on Power Electronics and Drive Systems (PEDS), Taipei, Taiwan, 2009, pp. 973-978, doi: 10.1109/PEDS. 2009.5385656.
[36] M. Tou, K. Al-Haddad, G. Olivier and V. Rajagopalan, “Analysis and design of single controlled switch three phase rectifier with unity power factor and sinusoidal input current,” Proceedings of the IEEE Applied Power Electronics Conference and Exposition - APEC'95, Dallas, TX, USA, 1995, pp. 856-862 vol.2, doi: 10.1109/APEC.1995.469041.
[37] D. Li, Y. Notohara, M. Sano and T. Ando, “Low-cost high-power-factor three-phase rectifier with turn-on current suppression circuit,” IEEE Energy Conversion Congress and Exposition, Denver, CO, USA, 2013, pp. 4872-4877, doi: 10.1109/ECCE.2013.6647356.
[38] F. M. Fernandez and P. S. C. Nair, “Influence of power factor compensating capacitors on estimation of harmonic distortion,” 9th IEEE International Conference on Electrical Power Quality and Utilisation, Barcelona, Spain, 2007, pp. 1-4, doi: 10.1109/EPQU.2007.4424128.
[39] M. H. Bhuyan, “Digital Signal Processor Controlled PWM Phase Modulator for Two Phase Voltage Source Inverter,” MSc Engg. Thesis, Department of Electrical and Electronic Engineering, Bangladesh University of Engineering and Technology, Dhaka, Bangladesh, 2002.